Adsorption of acid yellow dye 17 on activated carbon prepared from Euterpe oleracea: kinetic and thermodynamic studies
DOI:
https://doi.org/10.33448/rsd-v11i2.25556Keywords:
Adsorption; Activated carbon ; Acid yellow 17.Abstract
Environmental pollution has been a point of discussion in the international community and an object of investigation by research groups, which focus on the development of remediation methods. In the current study, the bunch of açaí (Euterpe oleracea) was used as a precursor for the preparation of low-cost activated carbon in order to remove the dye 17 AY 17 from the aqueous solution. The synthesis was carried out at temperatures of 500, 600 and 700 °C, for 2.0 h in a muffle furnace. The kinetic and thermodynamic mechanism of the adsorption process of the acid yellow dye 17, and the effects of pH, contact time and initial concentration were investigated. Activated carbon carbonized at 700 °C had the highest adsorption capacity, about of 99.9% of removal of the AY. The adsorption capacity of AY 17 was slightly pH dependent with a maximum value at pH 2.0. The kinetic data show that the equilibrium time was 200 min, and the adsorption capacity of activated carbon was 99.9% at 50 mg L‒1 and 67.0% at 150 mg L‒1 of adsorbate, suggesting high adsorption capacity of the material, even in the presence of high dye concentration. The adsorption process of AY 17 is described by the pseudo-second order kinetic model, and the experimental adsorption isotherms are adjusted to the Freundlich model, indicating that the adsorption of AY 17 on activated carbon occurs with the formation of multilayers. The present study shows that this low-cost material has great potential for remediation of textile effluents.
References
Abdulhameed, A. S., Mohammad, A. K. T., & Jawad, A. H. (2019). Application of response surface methodology for enhanced synthesis of chitosan tripolyphosphate/TiO2 nanocomposite and adsorption of reactive orange 16 dye. J. Clean. Prod., 232, 43–56. https://doi.org/10.1016/j.jclepro.2019.05.291.
Achour, Y., Bahsis, L., Ablouh, E. H., Yazid, H., Laamari, M. R., & Haddad, M. El (2021). Insight into adsorption mechanism of Congo red dye onto Bombax Buonopozense bark Activated-carbon using Central composite design and DFT studies. Surfaces and Interfaces, 23, 100977. https://doi.org/10.1016/j.surfin.2021.100977.
Ahmad, M. A., Ahmad Puad, N. A., & Bello, O. S. (2014). Kinetic, equilibrium and thermodynamic studies of synthetic dye removal using pomegranate peel activated carbon prepared by microwave-induced KOH activation. Water Resour. Ind., 6, 18–35. https://doi.org/10.1016/j.wri.2014.06.002.
Al-Ghouti, M. A., & Da’ana, D. A. (2020). Guidelines for the use and interpretation of adsorption isotherm models: A review. J. Hazard. Mater., 393, 122383. https://doi.org/10.1016/j.jhazmat.2020.122383.
Alam, M. M., Hossain, M. A., Hossain, M. D., Johir, M. A. H., Hossen, J., Rahman, M. S., Zhou, J. L., Hasan, A. T. M. K., Karmakar, A. K., & Ahmed, M. B. (2020). The potentiality of rice husk-derived activated carbon: From synthesis to application. Processes, 8. https://doi.org/10.3390/pr8020203.
Alkathiri, D. S. S., Sabri, M. A., Ibrahim, T. H., ElSayed, Y. A., & Jumean, F. (2020). Development of activated carbon fibers for removal of organic contaminants. Int. J. Environ. Sci. Technol., 17, 4841–4852. https://doi.org/10.1007/s13762-020-02808-8.
Ani, J. U., Akpomie, K. G., Okoro, U. C., Aneke, L. E., Onukwuli, O. D., & Ujam, O. T. (2020). Potentials of activated carbon produced from biomass materials for sequestration of dyes, heavy metals, and crude oil components from aqueous environment. Appl. Water Sci., 10, 1–11. https://doi.org/10.1007/s13201-020-1149-8.
Ashraf, M. A., Hussain, M., Mahmood, K., Wajid, A., Yusof, M., Alias, Y., & Yusoff, I. (2013). Removal of acid yellow-17 dye from aqueous solution using eco-friendly biosorbent. Desalin. Water Treat., 51, 4530–4545. https://doi.org/10.1080/19443994.2012.747187.
Benkhaya, S., M’ rabet, S., & El Harfi, A. (2020). A review on classifications, recent synthesis and applications of textile dyes. Inorg. Chem. Commun., 115, 107891. https://doi.org/10.1016/j.inoche.2020.107891.
Berradi, M., Hsissou, R., Khudhair, M., Assouag, M., Cherkaoui, O., El Bachiri, A., & El Harfi, A. (2019). Textile finishing dyes and their impact on aquatic environs. Heliyon, 5. https://doi.org/10.1016/j.heliyon.2019.e02711.
Bhomick, P. C., Supong, A., Baruah, M., Pongener, C., & Sinha, D. (2018). Pine Cone biomass as an efficient precursor for the synthesis of activated biocarbon for adsorption of anionic dye from aqueous solution: Isotherm, kinetic, thermodynamic and regeneration studies. Sustain. Chem. Pharm., 10, 41–49. https://doi.org/10.1016/j.scp.2018.09.001.
Bouhadjra, K., Lemlikchi, W., Ferhati, A., & Mignard, S. (2021). Enhancing removal efficiency of anionic dye (Cibacron blue) using waste potato peels powder. Sci. Rep., 11, 1–10. https://doi.org/10.1038/s41598-020-79069-5.
Bulca, Ö., Palas, B., Atalay, S., & Ersöz, G. (2021). Performance investigation of the hybrid methods of adsorption or catalytic wet air oxidation subsequent to electrocoagulation in treatment of real textile wastewater and kinetic modelling. J. Water Process Eng., 40. https://doi.org/10.1016/j.jwpe.2020.101821.
Castro, A. S., Franco, C. R., & Cidade, M. J. A. (2018). Adsorption of dyes indosol blue, Indosol orange and drimarene red in aqueous solution by white clay. Rev. Virtual Quim., 10, 1502–1515. https://doi.org/10.21577/1984-6835.20180102.
Chen, F., Zhu, J., Yang, Y., & Wang, L. (2020). Assessing environmental impact of textile production with water alkalization footprint. Sci. Total Environ., 719, 137522. https://doi.org/10.1016/j.scitotenv.2020.137522.
Delle Site, A. (2001). Factors affecting sorption of organic compounds in natural sorbent/water systems and sorption coefficients for selected pollutants. A review. J. Phys. Chem. Ref. Data, 30, 187–439. https://doi.org/10.1063/1.1347984.
Febrianto, J., Kosasih, A. N., Sunarso, J., Ju, Y. H., Indraswati, N., & Ismadji, S. (2009). Equilibrium and kinetic studies in adsorption of heavy metals using biosorbent: A summary of recent studies. J. Hazard. Mater., 162, 616–645. https://doi.org/10.1016/j.jhazmat.2008.06.042.
Felista, M. M., Wanyonyi, W. C., & Ongera, G. (2020). Adsorption of anionic dye (Reactive black 5) using macadamia seed Husks: Kinetics and equilibrium studies. Sci. African, 7, e00283. https://doi.org/10.1016/j.sciaf.2020.e00283.
Foo, K. Y., & Hameed, B. H. (2012). Preparation of activated carbon by microwave heating of langsat (Lansium domesticum) empty fruit bunch waste. Bioresour. Technol., 116, 522–525. https://doi.org/10.1016/j.biortech.2012.03.123.
Guaratini, C. C. I., & Zanoni, M. V. B. (2000). Corantes têxteis. Quim. Nova, 23, 71–78.
Habibi, A., Belaroui, L.S., Bengueddach, A., López Galindo, A., Sainz Díaz, C. I., & Peña, A. (2018). Adsorption of metronidazole and spiramycin by an Algerian palygorskite. Effect of modification with tin. Microporous Mesoporous Mater., 268, 293–302. https://doi.org/10.1016/j.micromeso.2018.04.020.
Hamza, W., Dammak, N., Hadjltaief, H. B., Eloussaief, M., & Benzina, M. (2018). Sono-assisted adsorption of Cristal Violet dye onto Tunisian Smectite Clay: Characterization, kinetics and adsorption isotherms. Ecotoxicol. Environ. Saf., 163, 365–371. https://doi.org/10.1016/j.ecoenv.2018.07.021.
Haseeb, M., Kot, S., Hussain, H. I., Mihardjo, L. W. W., & Saluga, P. (2020). Modelling the non-linear energy intensity effect based on a quantile-on-quantile approach: The case of textiles manufacturing in asian countries. Energies, 13. https://doi.org/10.3390/en13092229.
Hassaan, M. A., Nemr, A. El, & Madkour, F. F. (2016). Application of Ozonation and UV assisted Ozonation for Decolorization of Direct Yellow 50 in Sea water. Pharm. Chem. J., 3, 131–138.
Heidarinejad, Z., Dehghani, M. H., Heidari, M., Javedan, G., Ali, I., & Sillanpää, M. (2020). Methods for preparation and activation of activated carbon: a review. Environ. Chem. Lett., 18, 393–415. https://doi.org/10.1007/s10311-019-00955-0.
Hynes, N. R. J., Kumar, J. S., Kamyab, H., Sujana, J. A. J., Al-Khashman, O. A., Kuslu, Y., Ene, A., & Suresh Kumar, B. (2020). Modern enabling techniques and adsorbents based dye removal with sustainability concerns in textile industrial sector -A comprehensive review. J. Clean. Prod., 272, 122636. https://doi.org/10.1016/j.jclepro.2020.122636.
Ignachewski, F., Fujiwara, T., Química, D. De, Centro-oeste, U.E., Camargo, R., Sá, V. De, Pr, G., Física, D. De, Centro-oeste, U.E., Camargo, R., Sá, V. De, Pr, G., Carneiro, L.M., & Tauchert, E. (2010). Degradação de corantes reativos por processo foto-fenton envolvendo o uso de peneira molecular 4a modificada com fe3+. Quim. Nova, 33, 1640–1645.
Inyinbor, A. A., Adekola, F. A., & Olatunji, G. A. (2016). Kinetics, isotherms and thermodynamic modeling of liquid phase adsorption of Rhodamine B dye onto Raphia hookerie fruit epicarp. Water Resour. Ind., 15, 14–27. https://doi.org/10.1016/j.wri.2016.06.001.
Langmuir, I. (1918). Adsorption of Gases on Glass, Mica and Platinum. the Adsorption of Gases on Plane Surfaces of Glass, Mica and Platinum. J. Am. Chem. Soc., 40, 1361–1403.
Jain, S. N., Tamboli, S. R., Sutar, D. S., Jadhav, S. R., Marathe, J. V., Shaikh, A. A., & Prajapati, A. A. (2020). Batch and continuous studies for adsorption of anionic dye onto waste tea residue: Kinetic, equilibrium, breakthrough and reusability studies. J. Clean. Prod., 252, 119778. https://doi.org/10.1016/j.jclepro.2019.119778.
Jedynak, K., Wideł, D., & Rędzia, N. (2019). Removal of rhodamine b (A basic dye) and acid yellow 17 (an acidic dye) from aqueous solutions by ordered mesoporous carbon and commercial activated carbon. Colloids and Interfaces, 3. https://doi.org/10.3390/colloids3010030.
Kannaujiya, M. C., Prajapati, A. K., Mandal, T., Das, A. K., & Mondal, M. K. (2021). Extensive analyses of mass transfer, kinetics, and toxicity for hazardous acid yellow 17 dye removal using activated carbon prepared from waste biomass of Solanum melongena. Biomass Convers. Biorefinery., https://doi.org/10.1007/s13399-020-01160-8.
Karthik, V., Saravanan, K., Patra, C., Ushadevi, B., Vairam, S., & Selvaraju, N. (2019). Biosorption of Acid Yellow 12 from simulated wastewater by non-viable T. harzianum: kinetics, isotherm and thermodynamic studies. Int. J. Environ. Sci. Technol., 16, 6895–6906. https://doi.org/10.1007/s13762-018-2073-4.
Kataria, N., Garg, V. K., Jain, M., & Kadirvelu, K. (2016). Preparation, characterization and potential use of flower shaped Zinc oxide nanoparticles (ZON) for the adsorption of Victoria Blue B dye from aqueous solution. Adv. Powder Technol., 27, 1180–1188. https://doi.org/10.1016/j.apt.2016.04.001.
Khatri, J., Nidheesh, P. V., Anantha Singh, T. S., & Suresh Kumar, M. (2018). Advanced oxidation processes based on zero-valent aluminium for treating textile wastewater. Chem. Eng. J., 348, 67–73. https://doi.org/10.1016/j.cej.2018.04.074.
Khattab, T. A., Abdelrahman, M. S., & Rehan, M. (2020). Textile dyeing industry: environmental impacts and remediation. Environ. Sci. Pollut. Res., 27, 3803–3818. https://doi.org/10.1007/s11356-019-07137-z.
Kishor, R., Purchase, D., Saratale, G. D., Saratale, R. G., Ferreira, L. F. R., Bilal, M., Chandra, R., & Bharagava, R. N. (2021). Ecotoxicological and health concerns of persistent coloring pollutants of textile industry wastewater and treatment approaches for environmental safety. J. Environ. Chem. Eng., 9, 105012. https://doi.org/10.1016/j.jece.2020.105012.
Lang, W., Sirisansaneeyakul, S., Ngiwsara, L., Mendes, S., Martins, L.O., Okuyama, M., & Kimura, A. (2013). Characterization of a new oxygen-insensitive azoreductase from Brevibacillus laterosporus TISTR1911: Toward dye decolorization using a packed-bed metal affinity reactor. Bioresour. Technol., 150, 298–306. https://doi.org/10.1016/j.biortech.2013.09.124.
Li, J., Wang, S., Peng, J., Lin, G., Hu, T., & Zhang, L. (2018). Selective Adsorption of Anionic Dye from Solutions by Modified Activated Carbon. Arab. J. Sci. Eng., 43, 5809–5817. https://doi.org/10.1007/s13369-017-3006-0.
Machrouhi, A., Farnane, M., Elhalil, A., Elmoubarki, R., Abdennouri, M., Barka, N., Qourzal, S., & Tounsadi, H. (2018). Effectiveness of beetroot seeds and H3PO4 activated beetroot seeds for the removal of dyes from aqueous solutions. J. Water Reuse Desalin., 8, 522–531. https://doi.org/10.2166/wrd.2017.034.
Mahmoud, M. E., Abdelfattah, A. M., Tharwat, R. M., & Nabil, G. M. (2020). Adsorption of negatively charged food tartrazine and sunset yellow dyes onto positively charged triethylenetetramine biochar: Optimization, kinetics and thermodynamic study. J. Mol. Liq., 318, 114297. https://doi.org/10.1016/j.molliq.2020.114297.
Mane, V. S., Mall, I. D., & Srivastava, V. C. (2007). Use of bagasse fly ash as an adsorbent for the removal of brilliant green dye from aqueous solution. Dye. Pigment., 73, 269–278. https://doi.org/10.1016/j.dyepig.2005.12.006.
Munagapati, V. S., Wen, H. Y., Vijaya, Y., Wen, J. C., Wen, J. H., Tian, Z., Reddy, G. M., & Raul Garcia, J. (2021). Removal of anionic (Acid Yellow 17 and Amaranth) dyes using aminated avocado (Persea americana) seed powder: adsorption/desorption, kinetics, isotherms, thermodynamics, and recycling studies. Int. J. Phytoremediation, 23, 911–923. https://doi.org/10.1080/15226514.2020.1866491.
Nambela, L., Haule, L.V., & Mgani, Q. (2020). A review on source, chemistry, green synthesis and application of textile colorants. J. Clean. Prod., 246, 119036. https://doi.org/10.1016/j.jclepro.2019.119036.
Njoku, V. O., Foo, K. Y., Asif, M., & Hameed, B. H. (2014). Preparation of activated carbons from rambutan (Nephelium lappaceum) peel by microwave-induced KOH activation for acid yellow 17 dye adsorption. Chem. Eng. J., 250, 198–204. https://doi.org/10.1016/j.cej.2014.03.115.
Obaid, M. K., Abdullah, L. C., & Idan, I. J. (2016). Removal of Reactive Orange 16 Dye from Aqueous Solution by Using Modified Kenaf Core Fiber. J. Chem., 2016, 1–8. https://doi.org/10.1155/2016/4262578.
Panwar, N. L., & Pawar, A. (2020). Influence of activation conditions on the physicochemical properties of activated biochar: a review. Biomass Convers. Biorefinery., https://doi.org/10.1007/s13399-020-00870-3.
Paredes-Quevedo, L. C., González-Caicedo, C., Torres-Luna, J. A., & Carriazo, J. G. (2021). Removal of a Textile Azo-Dye (Basic Red 46) in Water by Efficient Adsorption on a Natural Clay. Water. Air. Soil Pollut., 232. https://doi.org/10.1007/s11270-020-04968-2.
Parveen, K., & Rafique, U. (2018). Development of cobalt-doped alumina hybrids for adsorption of textile effluents. Adsorpt. Sci. Technol., 36, 182–197. https://doi.org/10.1177/0263617416687563.
Patil, C., Ratnamala, G. M., Channamallayya, S. T., & Belagavi, K. (2015). Adsorption Studies for Removal of Acid yellow 17 using Activated Rice Husk. Inter. Res. J. of Eng. and Techn., 769–774.
Piccin, J. S., Dotto, G. L., & Pinto, L. A. A. (2011). Adsorption isotherms and thermochemical data of FDandC RED N° 40 Binding by chitosan. Brazilian J. Chem. Eng., 28, 295–304. https://doi.org/10.1590/S0104-66322011000200014.
Ghaly A. E, Ananthashankar R, Alhattab M, & Ramakrishnan V. V (2014). Production, Characterization and Treatment of Textile Effluents: A Critical Review. J. Chem. Eng. Process Technol., 05. https://doi.org/10.4172/2157-7048.1000182.
Raman, C. D., & Kanmani, S. (2016). Textile dye degradation using nano zero valent iron: A review. J. Environ. Manage., 177, 341–355. https://doi.org/10.1016/j.jenvman.2016.04.034.
Reza, M. S., Yun, C. S., Afroze, S., Radenahmad, N., Bakar, M. S. A., Saidur, R., Taweekun, J., & Azad, A. K. (2020). Preparation of activated carbon from biomass and its’ applications in water and gas purification, a review. Arab J. Basic Appl. Sci., 27, 208–238. https://doi.org/10.1080/25765299.2020.1766799.
Roy, U., Sengupta, S., Das, P., Bhowal, A., & Datta, S. (2018). Integral approach of sorption coupled with biodegradation for treatment of azo dye using Pseudomonas sp.: batch, toxicity, and artificial neural network. 3 Biotech, 8, 1–11. https://doi.org/10.1007/s13205-018-1215-1.
Saadi, R., Saadi, Z., Fazaeli, R., & Fard, N. E. (2015). Monolayer and multilayer adsorption isotherm models for sorption from aqueous media. Korean J. Chem. Eng., 32, 787–799. https://doi.org/10.1007/s11814-015-0053-7.
Salleh, M. A. M., Mahmoud, D. K., Karim, W. A. W. A., & Idris, A. (2011). Cationic and anionic dye adsorption by agricultural solid wastes: A comprehensive review. Desalination, 280, 1–13. https://doi.org/10.1016/j.desal.2011.07.019.
Sarkar, S., Banerjee, A., Halder, U., Biswas, R., & Bandopadhyay, R. (2017). Degradation of Synthetic Azo Dyes of Textile Industry: a Sustainable Approach Using Microbial Enzymes. Water Conserv. Sci. Eng., 2, 121–131. https://doi.org/10.1007/s41101-017-0031-5.
Shindhal, T., Rakholiya, P., Varjani, S., Pandey, A., Ngo, H. H., Guo, W., Ng, H. Y., & Taherzadeh, M. J. (2021). A critical review on advances in the practices and perspectives for the treatment of dye industry wastewater. Bioengineered, 12, 70–87. https://doi.org/10.1080/21655979.2020.1863034.
Shoaib, A. G. M., El-Sikaily, A., El Nemr, A., & Mohamed, A. E. D. A., Hassan, A. A. (2020). Preparation and characterization of highly surface area activated carbons followed type IV from marine red alga (Pterocladia capillacea) by zinc chloride activation. Biomass Convers. Biorefinery., https://doi.org/10.1007/s13399-020-00760-8.
Sing, K. S. W. (1982). Reporting physisorption data for gas / solid systems with Special Reference to the Determination of S. Pure Appl. Chem., 54, 2201–2218.
Srivastava, V. C., Swamy, M. M., Mall, I. D., Prasad, B., & Mishra, I. M. (2006). Adsorptive removal of phenol by bagasse fly ash and activated carbon: Equilibrium, kinetics and thermodynamics. Colloids Surfaces A Physicochem. Eng. Asp., 272, 89–104. https://doi.org/10.1016/j.colsurfa.2005.07.016.
Ugwu, E. I., & Agunwamba, J. C. (2020). A review on the applicability of activated carbon derived from plant biomass in adsorption of chromium, copper, and zinc from industrial wastewater. Environ. Monit. Assess., 192. https://doi.org/10.1007/s10661-020-8162-0.
Vacchi, F. I., Albuquerque, A. F., Vendemiatti, J. A., Morales, D. A., Ormond, A. B., Freeman, H. S., Zocolo, G. J., Zanoni, M. V. B., & Umbuzeiro, G. (2013). Chlorine disinfection of dye wastewater: Implications for a commercial azo dye mixture. Sci. Total Environ., 442, 302–309. https://doi.org/10.1016/j.scitotenv.2012.10.019.
Veit, M. T., Bedin, S., Gonçalves, G. C., Palácio, S. M., & Fagundes-Klen, M. R. (2014). Utilização do resíduo de erva-mate como material adsorvente do corante azul de metileno. Eclet. Quim., 39, 227–243.
Verma, K., Saha, G., Kundu, L. M., & Dubey, V. K. (2019). Biochemical characterization of a stable azoreductase enzyme from Chromobacterium violaceum: Application in industrial effluent dye degradation. Int. J. Biol. Macromol., 121, 1011–1018. https://doi.org/10.1016/j.ijbiomac.2018.10.133.
Yusop, M. F. M., Ahmad, M. A., Rosli, N. A., Gonawan, F. N., & Abdullah, S. J. (2021). Scavenging malachite green dye from aqueous solution using durian peel based activated carbon. Malaysian J. Fundam. Appl. Sci., 17, 95–103. https://doi.org/10.11113/MJFAS.V17N1.2173.
Zoroufchi Benis, K., Motalebi Damuchali, A., McPhedran, K. N., & Soltan, J. (2020). Treatment of aqueous arsenic – A review of biosorbent preparation methods. J. Environ. Manage., 273, 111126. https://doi.org/10.1016/j.jenvman.2020.111126.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2022 Deusimar de Oliveira Lopes; Lucas Oliveira Santos; Evair Dias Nascimento; Adriane Damasceno Vieira de Souza; Franscico Adriano de Oliveira Carvalho
This work is licensed under a Creative Commons Attribution 4.0 International License.
Authors who publish with this journal agree to the following terms:
1) Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
2) Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
3) Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work.
